Service Information and Revisions
RV-10 Service Bulletins
ID
Date Posted
Applies To
Description
Details
ID
SB-00002
Date Posted
November 5, 2020
Applies To
RV-10
Description
Describes change to RV-10 bottom rudder hinge bracket and method for inspection.
ID
SB-00006
Date Posted
May 6, 2020
Applies To
All RV models
Description
Potential leaking of Kavlico pressure sensors
ID
SB 19-09-09
Date Posted
February 26, 2020
Applies To
RV-10
Description
RV-10 updated nose gear leg
ID
SB 18-05-21
Date Posted
May 21, 2018
Applies To
All fuel injected Lycoming engine installations
Description
Proper installation of gauge plug in fuel spider
ID
SB 18-03-30
Date Posted
March 30, 2018
Applies To
RV-10
Description
Elevator control stop inspection
ID
MT SB 31
Date Posted
August 29, 2016
Applies To
All MT governors listed by type and serial number on page 3 and 4 which were manufactred from April 2010 until July 2013 installed on direct drive engines modified with electronic ignition or higher compression pistons.
Description
Flyweight failures
ID
SB 16-03-28
Date Posted
March 28, 2016
Applies To
All RV-3,4,6,7,8,9,10,14
Description
Cracking of wing aft spar web at the inboard aileron hinge bracket attach rivets.
ID
SB 14-12-22
Date Posted
December 22, 2014
Applies To
RV-6A,7A,8A,9A,10
Description
Nose Stop Flange Installation (before further flight)
ID
SB 14-8-29
Date Posted
August 29, 2014
Applies To
RV-10
Description
Engine Mount Elastomer Plate
ID
SB 11-9-13
Date Posted
September 13, 2011
Applies To
All RV Models
Description
Fuel Tank Slosh Inspection
ID
SB 10-1-4
Date Posted
January 4, 2010
Applies To
RV-10
Description
Install Door Safety Latch
ID
SB 08-6-1
Date Posted
June 1, 2008
Applies To
All RV-10 kits and completed aircraft
Description
F-1010 bulkhead reinforcement
ID
SB 07-4-12
Date Posted
April 12, 2007
Applies To
All RV models with electric flaps
Description
Securing flap motor rod end bearing
ID
SB 06-9-20
Date Posted
September 20, 2006
Applies To
All builders and operators of any model of a Van's Aircraft
Description
Trim Cable Anchor
ID
SB 06-2-3
Date Posted
February 3, 2006
Applies To
RV-10
Description
RV-10 Vertical Stabilizer
ID
SB 04-2-1
Date Posted
February 1, 2004
Applies To
Fuel Tanks
Description
Inspect Fuel Tanks
ID
SB 02-12-1
Date Posted
December 1, 2002
Applies To
Firewall Forward Kits and Pre-manufactured hose assemblies purchased prior to December 10, 2002
Description
Inspect Hoses
ID
SB 96-10-1
Date Posted
October 1, 1996
Applies To
All RV Aircraft except RV-12 and RV-14
Description
Filtered Airbox
RV-10 Notifications and Letters
ID
Date Posted
Applies To
Description
Details
ID
SL-00003
Date Posted
February 4, 2021
Applies To
RV-10
Description
Covers the optional removal of RV-10 tank attach angles where installed
ID
SL-00033 Rev 1
Date Posted
February 4, 2021
Applies To
RV-10
Description
Directs owners to inspect and provide reports on flying RV-10 aircraft; Revised and republished 2/4/2021
ID
N 14-07-03
Date Posted
July 3, 2014
Applies To
All Van’s Aircraft RV Models
Description
SAIB HQ-14-16 (all-metal lock nuts)
ID
N Fuel Valve Lever II Installation
Date Posted
December 20, 2011
Applies To
RV-3,4,6,7,8,9,10
Description
Fuel Valve Lever II installation
ID
N Buying a Flying RV
Date Posted
April 19, 2011
Applies To
Buying a Flying RV
Description
A letter to prospective buyers of flying RVs
ID
N RV-10 Door Latch Switches
Date Posted
February 13, 2008
Applies To
RV-10
Description
Door Latch Switches
ID
N Service Letter – Soft Rivets
Date Posted
November 26, 2007
Applies To
All RV kits
Description
Soft Rivets
ID
N Master Switch
Date Posted
November 16, 2007
Applies To
Master Switches shipped after 10/2/2007
Description
Inspect the back of the switch
ID
N RV-10 Motor Mount
Date Posted
January 15, 2007
Applies To
RV-10
Description
Motor/motor mount interference
ID
N Battery Cables
Date Posted
October 18, 2006
Applies To
All #2 battery cables
Description
Possible battery cable terminal failure
ID
N U-1023
Date Posted
September 21, 2006
Applies To
RV-10
Description
U-1023 nose wheel bearing spacers
ID
N Tunnel Temp
Date Posted
June 12, 2006
Applies To
RV-10
Description
Fuselage Tunnel Temperature
ID
N RV-10 Spur Gear
Date Posted
May 18, 2006
Applies To
RV-10
Description
Door Handle Spur Gear
ID
N 60 amp Alternator Wiring Change
Date Posted
February 13, 2006
Applies To
All users of a 60 amp Alternator
Description
60 amp Alternator Wiring Change
ID
N FAB SB 05
Date Posted
October 1, 2005
Applies To
All builders and operators of any model of a Van's Aircraft kit aircraft except RV-12
Description
Filtered Airbox Advisory
ID
N Buying a Used RV Kit
Date Posted
August 11, 2004
Applies To
Buying a second-hand RV Kit
Description
A letter to prospective buyers of a second-hand RV Kit
ID
N FAB SB 05 [superceded]
Date Posted
May 1, 2003
Applies To
Superceded by service letter October 1 2005
Description
Filtered Airbox Advisory
RV-10 Revisions and Changes
Note: The date in a document’s title will not be the same as the date on which the document is posted. Drawing date represents the date the change was proposed/started. Date posted represents the completion/release date. Some revisions take longer than others to complete. Reasons include complexity, discovery of additional items needing revision, dependencies on other changes, validation/testing, parts fabrication, etc.
Document Key:
KAI = Kit Assembly Instructions (Number in title indicates the plans section number)
MM = Maintenance Manual
POH = Pilot Operating Handbook
PAP = Production Acceptance Procedures
FTS = Flight Training Supplement
ID
Date Posted
Applies To
Description
Details
ID
Filtered Air Box (FAB) Instructions
Date Posted
June 2, 2021
Applies To
320/360/540 engines with vertical induction
Description
Changes made to Filtered Air Box kit for vertical induction engines. Includes new kit parts and assembly methods for improved alignment and carb heat air door changes.
ID
35
Date Posted
April 8, 2021
Applies To
RV-10
Description
Updated to include missing pages (see release notes)
ID
7_10
Date Posted
November 6, 2020
Applies To
RV-10
Description
Changes related to redesigned rudder bottom hinge bracket
ID
OP-60
Date Posted
September 24, 2019
Applies To
RV-7/7A, RV-9/9A, RV-10
Description
Steps to install new ADAHRS mounting brackets in RV-7, RV-9, RV-10
ID
OP-56
Date Posted
September 24, 2019
Applies To
All RV Models except RV-12/iS
Description
Changed part numbers
ID
OP-55
Date Posted
September 24, 2019
Applies To
All RV Models except RV-12/iS
Description
Updated part numbers
ID
48_10
Date Posted
May 21, 2019
Applies To
RV-10
Description
Changes made to include new/improved RV-10 wheelpant standoff parts.
ID
Section 3
Date Posted
October 2, 2014
Applies To
RV-3|RV-4|RV-6|RV-7|RV-8|RV-9|RV-10|RV-14
Description
Changes Made
